As the Gulf of Mexico disaster casts an ugly spotlight on the pitfalls of global oil dependency, Japan’s auto giants are moving into high gear in a drive to mass-market electric cars.
Nissan, Honda and Toyota are among car-makers now gambling that electric vehicles (EVs) with their zero tailpipe emissions will catch on and, some time in the future, start to drive traditional gas-guzzlers off the road.
If their bet pays off, green car proponents say, it could ring in a revolution that changes the very idea of what an automobile is, turning cars into electric appliances that drive smoothly, cleanly and silently.
PHOTO: AFP
US President Barack Obama called last Tuesday for a “national mission” to develop clean energy, speaking from the White House as gushing crude oil kept fueling his country’s worst environmental catastrophe.
“The tragedy unfolding on our coast is the most painful and powerful reminder yet that the time to embrace a clean energy future is now,” he said in a somber prime-time telecast.
Battery-powered cars will be a crucial part of that future, manufacturers promise, even as critics point to tough hurdles — including higher sticker prices and “range anxiety” — to gaining wide consumer acceptance.
An EV’s energy consumption and carbon footprint are determined by the way its battery is charged — meaning it can effectively be powered by anything from fossil fuel or nuclear plants to hydro, wind or solar energy.
A critical question will be whether sufficiently large networks of electric re-charging stations are built — a chicken-and-egg question that has long held back the development of EVs, analysts say.
Cars that can be charged like a cellphone by plugging them into a wall socket, preferably during overnight off-peak hours, promise to shield consumers from volatile petrol prices and be cheaper in the long run.
Another benefit is that they emit none of the tailpipe pollutants that have covered the skies over cities from Los Angeles to Mumbai in smog.
Their efficiency is boosted because they are lighter, have motors that directly power wheels, preserving energy otherwise lost in transmission, and because the battery charge is topped up by regenerative braking.
Bullish Nissan, part-owned by Renault of France, will in December roll out its Leaf — short for Leading Environmentally Friendly, Affordable Family car — as the world’s first mass-produced electric car.
The five-seater hatchback has a top speed above 140km per hour, a range of 160km and can be recharged in eight hours, or rapid-charged to 80 percent of capacity in 30 minutes.
“We do believe this car is a game-changer in terms of this technology, and it will play a role in the future,” Simon Thomas, Nissan’s senior vice president of sales and marketing, said in London last month.
Nissan plans to sell 50,000 EVs in the US, Japan and Europe per year next year and in 2012, and then 500,000 units in 2013. It predicts that by 2020 electric cars will account for 10 percent of the global auto market.
Although experts foresee revolutionary change, they disagree on the pace.
“This could be a new industrial revolution,” Tokai Tokyo Research Center analyst Mamoru Kato said. “With EVs, you will no longer need traditional auto parts makers. Carmakers will essentially become electronics makers.”
However, he predicted EVs won’t really take off for another 10 years.
“I think the hurdle for their popularization is very high,” he said. “It will take at least a decade to improve batteries so that they can sufficiently power vehicles. After that, it will take more years to build up infrastructure, like battery power stations.”
Questions remain about global standards for electric plug-in systems, and about the supply of lithium for batteries and their safe disposal.
Batteries now make up about half the price of an EV, typically between US$10,000 and US$20,000, and a key will be to make them cheaper and last longer, Mizuno Credit Advisory analyst Tatsuya Mizuno said.
“Generally, they have to increase performance while cutting prices,” he said. “It will be difficult. But prices of electronics parts are falling fast.”
Whatever the outlook, other major carmakers, among them General Motors, Ford, BMW and Daimler, plan to start selling EVs by 2013.
At home, Nissan will go head-to-head with Mitsubishi Motors which launched its all electric “i-MiEV” compact a year ago. Toyota, which has for more than a decade sold gasoline-electric hybrids such as the Prius, has promised to launch its own electric car by 2012.
Last month it bought a US$50 million stake in Tesla Motors, a Palo Alto, California start-up that in 2004 began developing its Roadster, a boutique, “highway-ready” electric sports car with a range of about 394km.
The Silicon Valley firm this year also bought the former NUMMI factory in Fremont, California, which until recently made Toyota’s Corolla and Tacoma vehicles, to build its Model S sedan and future Tesla vehicles.
Some industry players may leapfrog to EVs, PriceWaterhouseCoopers said in a recent report, pointing to the “changing geography of the automotive industry.”
“Chinese automakers, for example, understand it will behoove them to focus on developing electric vehicles rather than committing major resources to catching up on internal combustion engine standards,” it said.
In many countries, electric charging networks are now being built. The company Better Place has built up EV infrastructure in Denmark and Israel where drivers can either recharge or swap batteries, focusing on customers such as government agencies and taxi fleets.
Nissan says it has partnered with 50 groups and communities around the world, from Australia’s capital Canberra to parts of England, to introduce EVs with subsidies and benefits such as dedicated highway lanes.
California is shaping up as the US test-bed for EVs, with the government offering rebates and backing a network of more than 5,000 charging stations, set to be up and running by 2012.
Many will be at locations where people spend time — including restaurants, hotels, malls and churches — and some major retailers plan to offer electricity for free to attract customers, Dow Jones has reported.
In Japan pilot programs in tourist spots and by city governments have given many people a taste of driving an EV.
A citizens group, the Japan Electric Vehicle Club, has fueled the buzz. In May it claimed a new world record when it drove an EV fitted with a stack of lithium ion batteries, for 1,003km on a single charge.
Taiwan Transport and Storage Corp (TTS, 台灣通運倉儲) yesterday unveiled its first electric tractor unit — manufactured by Volvo Trucks — in a ceremony in Taipei, and said the unit would soon be used to transport cement produced by Taiwan Cement Corp (TCC, 台灣水泥). Both TTS and TCC belong to TCC International Holdings Ltd (台泥國際集團). With the electric tractor unit, the Taipei-based cement firm would become the first in Taiwan to use electric vehicles to transport construction materials. TTS chairman Koo Kung-yi (辜公怡), Volvo Trucks vice president of sales and marketing Johan Selven, TCC president Roman Cheng (程耀輝) and Taikoo Motors Group
Among the rows of vibrators, rubber torsos and leather harnesses at a Chinese sex toys exhibition in Shanghai this weekend, the beginnings of an artificial intelligence (AI)-driven shift in the industry quietly pulsed. China manufactures about 70 percent of the world’s sex toys, most of it the “hardware” on display at the fair — whether that be technicolor tentacled dildos or hyper-realistic personalized silicone dolls. Yet smart toys have been rising in popularity for some time. Many major European and US brands already offer tech-enhanced products that can enable long-distance love, monitor well-being and even bring people one step closer to
RECORD-BREAKING: TSMC’s net profit last quarter beat market expectations by expanding 8.9% and it was the best first-quarter profit in the chipmaker’s history Taiwan Semiconductor Manufacturing Co (TSMC, 台積電), which counts Nvidia Corp as a key customer, yesterday said that artificial intelligence (AI) server chip revenue is set to more than double this year from last year amid rising demand. The chipmaker expects the growth momentum to continue in the next five years with an annual compound growth rate of 50 percent, TSMC chief executive officer C.C. Wei (魏哲家) told investors yesterday. By 2028, AI chips’ contribution to revenue would climb to about 20 percent from a percentage in the low teens, Wei said. “Almost all the AI innovators are working with TSMC to address the
Malaysia’s leader yesterday announced plans to build a massive semiconductor design park, aiming to boost the Southeast Asian nation’s role in the global chip industry. A prominent player in the semiconductor industry for decades, Malaysia accounts for an estimated 13 percent of global back-end manufacturing, according to German tech giant Bosch. Now it wants to go beyond production and emerge as a chip design powerhouse too, Malaysian Prime Minister Anwar Ibrahim said. “I am pleased to announce the largest IC (integrated circuit) Design Park in Southeast Asia, that will house world-class anchor tenants and collaborate with global companies such as Arm [Holdings PLC],”