New York City is in the midst of a plumbing repair job of monumental proportions.
Hard-hat workers are toiling deep underground, 55 stories beneath the Hudson River, to eliminate gushing leaks in an aging tunnel that carries half the city’s water supply more than 135km from Catskill Mountain reservoirs.
Using a cylindrical, space-rocket-size borer, they are carving through solid rock to create a 4km bypass tunnel around the worst of the leaks.
Photo: AP
When they finish the US$1 billion tunnel in 2022, the entire Delaware Aqueduct will be shut down for months to prepare for the diversion.
And if they do it right, New Yorkers turning on their faucets will never even notice.
COMPLEX REPAIR
“It’s really the largest and most complex water tunnel repair that the city of New York has ever done,” New York City Department of Environmental Protection Commissioner Vincent Sapienza said. “There’s a lot of moving parts that we’ve been wrestling with for several years now.”
The Delaware Aqueduct is to the city what the aorta is to our circulatory systems: a necessary channel to keep everything running. It was drilled and blasted out mostly during World War II and carries about 2.27 billion liters a day, entirely by gravity, from four Catskill region reservoirs to a holding reservoir just north of the city line.
Along with the complementary Catskill Aqueduct, the two help connect a complex system that serves 9.6 million people in New York City and upstate municipalities.
Engineers and politicians compare the network of 19 reservoirs, three lakes and connecting tunnels to the grand aqueducts of ancient Rome.
However, the Delaware Aqueduct is showing its age at a weak point where it crosses through limestone beneath the Hudson River near Newburgh, New York.
Limestone is less dense and has more “give” than the neighboring shale, so crews protected that length of the concrete tunnel with a steel sleeve.
However, for an unknown reason — lack of foresight, lack of steel during wartime — they did not extend it through the entire limestone formation.
Leaks formed in that gap, with some of the water burbling up into the river.
About 68 million liters — 3 percent of the aqueduct’s flow, or enough to fill about 27 Olympic-size swimming pools — escapes from the pipeline every day. The loss is too big to ignore, but the tunnel is too vital to simply drain for a multiyear repair.
City officials eventually settled on the parallel bypass tunnel, which allows for a shutdown measured in months instead of years.
“We couldn’t fathom shutting down the tunnel,” department Deputy Commissioner Paul Rush said.
Workers began digging two giant access holes on either side of the river in 2013, and actual tunneling started last summer.
A long, cylindrical machine nicknamed “Nora” presses into the rock face with a spinning 6.6m “cutter head” embedded with 41 spinning, steel blades. The tunnel boring machine, the sort used worldwide for major water and transportation projects, is named for civil engineer Nora Stanton Blatch Deforest Barney.
The pulverized rock comes out the back via conveyor belt to be loaded onto rail cars and hauled topside. Dozens of workers are deep down at a time. They work Nora’s controls, bolt together pieces of the ever-lengthening concrete tunnel, operate rail cars and tend to material going up and down the 274m shaft.
It is a construction site in a cave — and a wet one at that. Miners are constantly sloshing through puddles from the seeping groundwater.
Draining the aqueduct in 2022 will give crews time to reroute the water under the Hudson and to seal other leaks about 40km up the aqueduct.
Those losses in Wawarsing, New York, are far smaller, but they did contribute to a local plague of flooded basements and sodden lawns that resulted in the government buying some homes.
CONSERVATION HELPS
Cutting off half the city’s water supply for up to eight months sounds like a recipe for disaster, but the environmental agency has been preparing for years.
Conservation efforts, like the installation of low-flow toilets, have contributed to dropping water usage rates even as the city grew.
The city will rely on water from reservoirs in suburban Westchester County and the Catskill Aqueduct, which should have a higher capacity by then. That aqueduct will be shut down for several 10-week increments so crews can scrub out microorganisms that have created a layer of “biofilm,” which inhibits the flow through the century-old tunnel.
By 2023, water will flow through a bypass built to last. A layer of steel will be fitted inside this tunnel and then another layer of concrete added for a final 4.3m-diameter tunnel, all the way through the limestone formation.
“We don’t plan to come down again anytime soon,” Rush said.
‘IN A DIFFERENT PLACE’: The envoy first visited Shanghai, where he attended a Chinese basketball playoff match, and is to meet top officials in Beijing tomorrow US Secretary of State Antony Blinken yesterday arrived in China on his second visit in a year as the US ramps up pressure on its rival over its support for Russia while also seeking to manage tensions with Beijing. The US diplomat tomorrow is to meet China’s top brass in Beijing, where he is also expected to plead for restraint as Taiwan inaugurates president-elect William Lai (賴清德), and to raise US concerns on Chinese trade practices. However, Blinken is also seeking to stabilize ties, with tensions between the world’s two largest economies easing since his previous visit in June last year. At the
Nearly half of China’s major cities are suffering “moderate to severe” levels of subsidence, putting millions of people at risk of flooding, especially as sea levels rise, according to a study of nationwide satellite data released yesterday. The authors of the paper, published by the journal Science, found that 45 percent of China’s urban land was sinking faster than 3mm per year, with 16 percent at more than 10mm per year, driven not only by declining water tables, but also the sheer weight of the built environment. With China’s urban population already in excess of 900 million people, “even a small portion
UNSETTLING IMAGES: The scene took place in front of TV crews covering the Trump trial, with a CNN anchor calling it an ‘emotional and unbelievably disturbing moment’ A man who doused himself in an accelerant and set himself on fire outside the courthouse where former US president Donald Trump is on trial has died, police said yesterday. The New York City Police Department (NYPD) said the man was declared dead by staff at an area hospital. The man was in Collect Pond Park at about 1:30pm on Friday when he took out pamphlets espousing conspiracy theories, tossed them around, then doused himself in an accelerant and set himself on fire, officials and witnesses said. A large number of police officers were nearby when it happened. Some officers and bystanders rushed
Beijing is continuing to commit genocide and crimes against humanity against Uyghurs and other Muslim minorities in its western Xinjiang province, U.S. Secretary of State Antony Blinken said in a report published on Monday, ahead of his planned visit to China this week. The State Department’s annual human rights report, which documents abuses recorded all over the world during the previous calendar year, repeated language from previous years on the treatment of Muslims in Xinjiang, but the publication raises the issue ahead of delicate talks, including on the war in Ukraine and global trade, between the top U.S. diplomat and Chinese