"OK, you hit this button," says Alan Cocconi, pointing to a control on a little G-force meter attached to his dashboard. "Then hold down the brake really hard. Push on it with all your might. When it says `Go,' let off the brake and hold on."
With that he steps out of the car. A flat, stretch of asphalt is dead ahead; alongside lies the runway of Brackett Field Airport east of Los Angeles.
With the throttle and brake pedals fully pressed, the bright yellow sports car shudders with power -- but rather than the roar of a caged Lamborghini, the only sound is a muffled whine. Though the whine becomes only marginally louder when the brakes are released, everything else changes as the car lunges forward in a jaw-dropping, stomach-clenching and near-terrifying blur. In less than 4 seconds, it's all over. The Tzero by AC Propulsion, has reached 100kph. And its only power is from a simple array of lithium-ion laptop computer batteries.
PHOTO: NY TIMES
Few street-legal automobiles are capable of running to 100kph in under four seconds, and it's a safe bet that the Tzero is the only electric-powered car that can. The founders of AC Propulsion, based in San Dimas in the suburbs east of Los Angeles, seem to think that the lithium-ion batteries have led them to the holy grail of electric motoring: range and performance in one package. This is, however, after the major automakers have cast aside ideas of all-electric vehicles and turned their attention to hybrids and fuel cells.
Thunderously fast but whisper quiet, the rear-wheel-drive Tzero began life in the late 1990s as a showcase for AC Propulsion's high-revving AC 150 drive system. A 220-horsepower street-legal racer, the car was powered by a series of deep-cycle automotive lead acid batteries. With 570kg of batteries on board, the original car was good to reach 100kph in just over 4 seconds with a top speed of 144kph and a range of 130km to 145km.
Last month, however, AC Propulsion unveiled the latest version of the car, now powered by 6,800 lightweight lithium-ion laptop computer batteries. With these batteries -- and an increased top speed -- the Tzero weighs 316kg less and the company says it will run up to 480km on a single charge -- which requires a few hours plugged into a 220-volt outlet like the ones many households have for clothes dryers. It can also be recharged at a 110-volt outlet, but it takes about three times as long.
The car, priced at US$220,000, is available only directly from AC Propulsion and has not yet met federal safety regulations. The company says, though, that it is legal for street use when registered as a "special construction vehicle," which is the way homemade and kit-built cars are registered. The Tzero at the speedway had a California license plate and had been driven to the track. So far, the company said, deposits have been made for eight cars with the lithium-ion system. (Two earlier versions, with lead acid batteries, were sold for private use.)
What will a Tzero buyer get?
The Tzero beats the acceleration US$281,000 Lamborghini Murcielago, the US$224,000 Ferrari 575M Maranello or the US$440,000 Porsche Carrera GT. And do it cleanly and quietly. However, with the single-gear Tzero's engine limited to just over 160kph at 13,300 rpm's, it will never win an oval-track race against those supercars.
But its developers are betting that the car's power and range will generate renewed interest not only in their company' race car driver and an engineer. Cocconi founded AC Propulsion just over a decade ago after having worked for General Motors as a founding engineer on the company's Saturn EV1 electric car project. Cocconi said he decided to go out on his own after GM decided to build the car.
"I didn't want to be a part of the big GM machine," he said. "About a month afterward, I thought about upgraded chargers and what techniques were possible and I started AC Propulsion." With that, he ripped the engine and transmission out of a Honda CRX and set to work devising his own drive system. Today, 250,000km later, he said, that Honda is still humming.
Gage met Cocconi while working as an automotive industry consultant on electric vehicles in the early '90s. "When I interviewed Alan," Gage said, "it became obvious that not only did he clearly know what he was talking about, but he was doing something about it. I drove a prototype of his and was blown away." A year later, he said, the consulting work dried up and he joined AC Propulsion.
The company's early days coincided with California's Zero Emissions Vehicle or ZEV mandate. When it appeared that automakers would be required to sell a substantial number of ZEVs, manufacturers were a primary customer for AC Propulsion's systems for evaluation.
When the mandate was challenged by manufacturers in 2001, Cocconi said, sales dried up. Today the company sells its US$25,000 EV conversions to private enthusiasts and to bus companies. Gage said that the lithium-ion setup, and plans to offer a conversion system for Toyota's Scion xB, could chart a new course for a company that today has only 12 full-time employees. Gage said that he and Cocconi realized that they could never produce a car with the economies of scale of a Honda or a Toyota.
"That's how the Tzero was born; it's a niche," Gage said. "We knew it would be expensive because it was hand-built in-house, but it would justify its price because it would have outstanding performance."
RETHINK? The defense ministry and Navy Command Headquarters could take over the indigenous submarine project and change its production timeline, a source said Admiral Huang Shu-kuang’s (黃曙光) resignation as head of the Indigenous Submarine Program and as a member of the National Security Council could affect the production of submarines, a source said yesterday. Huang in a statement last night said he had decided to resign due to national security concerns while expressing the hope that it would put a stop to political wrangling that only undermines the advancement of the nation’s defense capabilities. Taiwan People’s Party Legislator Vivian Huang (黃珊珊) yesterday said that the admiral, her older brother, felt it was time for him to step down and that he had completed what he
Taiwan has experienced its most significant improvement in the QS World University Rankings by Subject, data provided on Sunday by international higher education analyst Quacquarelli Symonds (QS) showed. Compared with last year’s edition of the rankings, which measure academic excellence and influence, Taiwanese universities made great improvements in the H Index metric, which evaluates research productivity and its impact, with a notable 30 percent increase overall, QS said. Taiwanese universities also made notable progress in the Citations per Paper metric, which measures the impact of research, achieving a 13 percent increase. Taiwanese universities gained 10 percent in Academic Reputation, but declined 18 percent
CHINA REACTS: The patrol and reconnaissance plane ‘transited the Taiwan Strait in international airspace,’ the 7th Fleet said, while Taipei said it saw nothing unusual The US 7th Fleet yesterday said that a US Navy P-8A Poseidon flew through the Taiwan Strait, a day after US and Chinese defense heads held their first talks since November 2022 in an effort to reduce regional tensions. The patrol and reconnaissance plane “transited the Taiwan Strait in international airspace,” the 7th Fleet said in a news release. “By operating within the Taiwan Strait in accordance with international law, the United States upholds the navigational rights and freedoms of all nations.” In a separate statement, the Ministry of National Defense said that it monitored nearby waters and airspace as the aircraft
UNDER DISCUSSION: The combatant command would integrate fast attack boat and anti-ship missile groups to defend waters closest to the coastline, a source said The military could establish a new combatant command as early as 2026, which would be tasked with defending Taiwan’s territorial waters 24 nautical miles (44.4km) from the nation’s coastline, a source familiar with the matter said yesterday. The new command, which would fall under the Naval Command Headquarters, would be led by a vice admiral and integrate existing fast attack boat and anti-ship missile groups, along with the Naval Maritime Surveillance and Reconnaissance Command, said the source, who asked to remain anonymous. It could be launched by 2026, but details are being discussed and no final timetable has been announced, the source