Thu, Feb 09, 2012 - Page 10 News List

Qantas grounds A380 over wing cracks

AP, SYDNEY

Australia’s Qantas Airways yestereday said it was temporarily grounding one of its A380 superjumbos after discovering dozens of hairline cracks in its wings during a maintenance inspection.

The Australian flagship carrier said the 36 small fissures posed no threat to safety, and that the cracks were different from the cracks that manufacturer Airbus found in metal brackets inside the wings of two jets last month. That discovery prompted Europe’s air safety authority to order the inspection of nearly a third of the world’s A380s.

Qantas workers found the cracks, measuring less than 2cm long, in the “wing rib feet” — the metal brackets that connect the wing’s ribs to its skin — after the aircraft hit severe turbulence on a flight from London to Singapore last month. The cracks were not related to the turbulence and were linked to an Airbus manufacturing issue, the airline said in a statement.

Qantas conducted routine checks after the turbulence incident, then conducted “additional precautionary inspections” on the wings at Airbus’ request, the airline said. The cracking was discovered in the precautionary inspections, Qantas said.

Qantas is working to repair the cracks and said it expects the plane to be back in the air within a week.

Qantas spokesman Tom Woodward said the cracks are the same type the airline recently found in the wing ribs of an A380 that is being repaired in Singapore following the disintegration of an engine in midflight in 2010. The 2010 engine failure was the most significant safety issue an A380 has faced since it began passenger flights in 2007, and prompted airlines to temporarily ground 20 of the planes.

When asked whether the recent discovery would prompt Qantas inspections of all 12 of its A380s, Woodward suggested they would not.

This story has been viewed 2886 times.
TOP top